Sludge holding tanks performance in wastewater treatment: Techno-economic assessment
DOI:
https://doi.org/10.15243/jdmlm.2025.124.8035Keywords:
excess sludge , sludge holding, sludge management , sludge storage, wastewater treatmentAbstract
This study evaluates the performance and economic viability of sludge holding tanks in wastewater treatment, focusing on their role in sludge management, particularly in Egypt’s expanding wastewater infrastructure. Despite their widespread use, sludge holding tanks lack standardized design and operational guidelines. This research addresses this gap by assessing operational parameters, design criteria, and economic impacts, especially for small-scale treatment plants. A pilot-scale sludge holding tank was tested in two phases: the first examined the effects of retention time and air mixing rates on waste-activated sludge (WAS) treatment, while the second investigated the impact of increased solids loading by adding primary sludge. Results indicate that sludge holding tanks primarily function as thickening units, with optimal performance at retention times of 23-26 hours and air mixing rates of 1.3-6 m³/hr/m³. Lower air mixing rates improved thickening efficiency, achieving dry solids content of up to 1.5%, suitable for dewatering. The addition of primary sludge further enhanced thickening, underscoring the importance of sludge composition. Economically, these tanks are more cost-effective than traditional thickeners and digesters, requiring less volume and lower operational costs. Although effluent quality may not match advanced treatment units, their simplicity and affordability make them ideal for small-scale facilities. The study provides practical recommendations for optimizing sludge holding tanks, contributing to more sustainable and efficient sludge management strategies.
References
Abdel Wahaab, R., Mahmoud, M. and van Lier, J.B. 2020. Toward achieving sustainable management of municipal wastewater sludge in Egypt: The current status and future perspective. Renewable and Sustainable Energy Reviews 127. https://doi.org/10.1016/j.rser.2020.109880
Andreoli, C.V., von Sperling, M. and Fernandes, F. 2007. Sludge Treatment and Disposal. London, UK: IWA Publishing. https://doi.org/10.2166/9781780402086
Anjum, M., Al-Makishah, N.H. and Barakat, M.A. 2016. Wastewater sludge stabilization using pre-treatment methods. Process Safety and Environmental Protection 102:865-875. https://doi.org/10.1016/j.psep.2016.05.022
Appels, L., Baeyens, J., Degrève, J. and Dewil, R. 2008. Principles and potential of the anaerobic digestion of waste-activated sludge. Progress in Energy and Combustion Science 34(6):755-781. https://doi.org/10.1016/j.pecs.2008.06.002
Arunachalam, R.S., Shah, H.K. and Ju, L.-K. 2004. Aerobic sludge digestion under low dissolved oxygen concentrations. Water Environment Research 76(5):453-462. https://doi.org/10.2175/106143004X151536
Bae, B.-U. and Kim, Y.-I. 2008. Application of solid loading rate and limiting solid flux to optimal design of gravitational thickeners in water treatment plants. Environmental Engineering Science 25(9):1281-1287. https://doi.org/10.1089/ees.2007.0178
Davis, M.L. 2010. Water and Wastewater Engineering: Design Principles and Practice. New York, NY, USA: McGraw-Hill Education.
Demirbas, A., Coban, V., Taylan, O. and Kabli, M. 2017. Aerobic digestion of sewage sludge for waste treatment. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects 39(21):2152-2158. https://doi.org/10.1080/15567036.2017.1289282
El Balad. 2022. Ministry of Housing: Implementation of 510 Wastewater Treatment Plants in the Governorates. Accessed 23 December 2024.
El-Sayed, S.A., Mohamed, S.A. and Taha, M.M. 2014. Quantitative appraisal of biomass resources and their energy potential in Egypt. Renewable and Sustainable Energy Reviews 30:473-482. https://doi.org/10.1016/j.rser.2013.03.014
Ghazy, M., Dockhorn, T. and Dichtl, N. 2009. Sewage sludge management in Egypt: Current status and perspectives towards a sustainable agricultural use. International Journal of Environmental, Chemical, Ecological, Geological and Geophysical Engineering 3(9):267-278.
Ghazy, M.R., Dockhorn, T. and Dichtl, N. 2011. Economic and environmental assessment of sewage sludge treatment processes application in Egypt. International Water Technology Journal 1(2):1-17.
Guyer, J.P. 2011. An Introduction to Sludge Handling, Treatment, and Disposal. Continuing Education and Development, Inc. [online]. Accessed 19 January 2019.
Kazimierczak, M. 2012. Sewage sludge stabilization indicators in aerobic digestion – a review. Annals of Warsaw University of Life Sciences – SGGW, Land Reclamation 44(2):101-109. https://doi.org/10.2478/v10060-011-0066-9
Luo, H., Zhang, D., Taylor, M., Nguyen, C. and Wang, Z.W. 2021. Aeration in sludge holding tanks as an economical means for biosolids odor control—A case study. Water Environment Research 93(10):1808-1818. https://doi.org/10.1002/wer.1582
Merlo, R.P., Trussell, R.S., Hermanowicz, S.W. and Jenkins, D. 2007. Effects of sludge properties on the thickening and dewatering of waste activated sludge. Water Environment Research 79(12):2412-2419. https://doi.org/10.2175/106143007X183925
Metcalf and Eddy, Inc., revised by Tchobanoglous, G., Burton, F.L. and Stensel, H.D. 2014. Wastewater Engineering: Treatment and Resource Recovery, 5th ed. New York, NY, USA: McGraw-Hill Education.
Ministry of Housing and Urban Affairs (MOHUA). n.d. Chapter 6: Design and construction of sludge treatment facilities. Accessed 19 January 2019.
Ortiz, A., Garcia, J., Uggetti, E. and Diez-Montero, R. 2022. Optimization of multi-stage thickening of biomass in a demonstrative full–scale microalgae-based wastewater treatment system. Separation and Purification Technology 281:119830. https://doi.org/10.1016/j.seppur.2021.119830
Pinto, N., Carvalho, A., Pacheco, J. and Duarte, E. 2016. Study of different ratios of primary and waste activated sludges to enhance the methane yield. Water and Environment Journal 30(1):82-87. https://doi.org/10.1111/wej.12188
Sanin, F.D., Clarkson, W.W. and Vesilind, P.A. 2011. Sludge Engineering: The Treatment and Disposal of Wastewater Sludges. DEStech Publications, Inc. Lancaster, PA.
Sudjit, S. n.d. Solid handling systems for organic sludge. SUT/Env. Unit Operations. Accessed 19 January 2019.
Tomei, M.C., Bertanza, G., Canato, M., Heimersson, S., Laera, G. and Svanstrom, M. 2016. Techno-economic and environmental assessment of upgrading alternatives for sludge stabilization in municipal wastewater treatment plants. Journal of Cleaner Production 112(4):3106-3115. https://doi.org/10.1016/j.jclepro.2015.10.017
U.S. Environmental Protection Agency (EPA). 1979. Process Design Manual for Sludge Treatment and Disposal. Municipal Enviromental Research Laboratory, Office of Research and Development, U.S. Enviromental Protection Agency.
van Haandel, C. and van der Lubbe, J.G.M. 2012. Handbook of Biological Wastewater Treatment: Design and Optimization of Activated Sludge Systems, 2nd ed. London, UK: IWA Publishing.
Vanyushina, A.Ya., Agarev, A.M., Moyzhes, S.I., Nikolaev, Y.A., Kevbrina, M.V. and Kozlov, M.N. 2012. Comparison of different thickening methods for active biomass recycle for anaerobic digestion of wastewater sludge. Water Science and Technology 66(8):1787-1793. https://doi.org/10.2166/wst.2012.405
Von Sperling, M. and Chernicharo, C.A.L. 2005. Biological Wastewater Treatment in Warm Climate Regions. London, UK: IWA Publishing.
Wang, X., Cui, B., Wei, D., Song, Z., He, Y. and Bayly, A.E. 2021. CFD simulation of tailings slurry thickening in a gravity thickener. Powder Technology 392:639-649. https://doi.org/10.1016/j.powtec.2021.07.047
Wei, Y., Van Houten, R.T., Borger, A.R., Eikelboom, D.H. and Fan, Y. 2003. Minimization of excess sludge production for biological wastewater treatment. Water Research 37(18). https://doi.org/10.1016/S0043-1354(03)00441-X
Ye, F.-X., Zhu, R.-F. and Li, Y. 2008. Effect of sludge retention time in sludge holding tank on excess sludge production in the oxic-settling-anaerobic (OSA) activated sludge process. Journal of Chemical Technology and Biotechnology 83(1):109-114. https://doi.org/10.1002/jctb.1781
Youm7. 2022. Deputy Minister of Housing Participates in the Cairo Water Week Activities in 2022. [Online]. Accessed 23 December 2024, https://www.youm7.com (in Arabic).
Zaher, U., Grau, P., Benedetti, L., Ayesa, E., Vanrolleghem, P.A. and Comeau, Y. 2007. Impact of sludge thickening on energy recovery from anaerobic digestion. Water Science and Technology 56(10):145-153, November 2007. IWA Publishing. https://doi.org/10.2166/wst.2007.755
Zhang, Q., Hu, J., Lee, D.-J., Chang, Y. and Lee, Y.-J. 2017. Sludge treatment: Current research trends. Bioresource Technology 243, November 2017:1159-1172. https://doi.org/10.1016/j.biortech.2017.07.070
Zhang, Y., Wang, H., Qi, L., Liu, G., He, Z. and Jiang, S. 2014. Simple model of sludge thickening process in secondary settlers. Frontiers of Environmental Science and Engineering 10:319-326. https://doi.org/10.1007/s11783-014-0758-6
Zhang, Y., Yin, X., He, Z., Zhang, X., Wen, Y. and Wang, H. 2015. Modeling the activated sludge—thickening process in secondary settlers. International Journal of Environmental Research and Public Health 12(12):15449-15458. https://doi.org/10.3390/ijerph121214996
Downloads
Submitted
Accepted
Published
How to Cite
Issue
Section
License
Copyright (c) 2025 Journal of Degraded and Mining Lands Management
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
Submission of a manuscript implies: that the work described has not been published before (except in the form of an abstract or as part of a published lecture, or thesis) that it is not under consideration for publication elsewhere; that if and when the manuscript is accepted for publication, the authors agree to automatic transfer of the copyright to the publisher. 
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
Scientific Journal by Eko Handayanto is licensed under a Creative Commons Attribution 4.0 International License.
Based on a work at https://ub.ac.id.
Permissions beyond the scope of this license may be available at https://ircmedmind.ub.ac.id/.
This work is licensed under a 